RTO（蓄热式热氧化)，是一种配有蓄热床层的热力燃烧方式。蓄热燃烧系统主要由燃烧装置、蓄热室（内有蓄热体)、换向系统、排烟系统

RTO (Regenerative Thermal Oxidation) is a thermal combustion method equipped with a thermal storage bed. The thermal storage combustion system mainly consists of a combustion device, a thermal storage chamber (with a thermal storage body inside), a reversing system, and a smoke exhaust system

和连接管道五部分组成。用于处理VOCs的蓄热燃烧系统至少配有两个蓄热室，交替进行蓄热和放热作业；若处理废气易导致蓄热体玷污，还需

It consists of five parts connected to the pipeline. The thermal storage combustion system used for treating VOCs is equipped with at least two thermal storage chambers, which alternate between thermal storage and heat release operations; If the treatment of exhaust gas can easily cause contamination of the thermal storage body, it is necessary to

配备清洗室，构成三室（或多室）式蓄热燃烧系统。现阶段RTO技术已越来越广泛地应用于印刷、涂布、化工、制药、喷涂等高污染行业产生

Equipped with a cleaning chamber, forming a three chamber (or multi chamber) regenerative combustion system. At present, RTO technology has been increasingly widely applied in high pollution industries such as printing, coating, chemical, pharmaceutical, and spray painting

的VOCs，并取得了较好的处理效益。

VOCs have been identified and achieved good treatment efficiency.

三室RTO焚烧炉是目前主流的应用装置，其工作原理为：将有机废气加热至760度以上，使废气中的有机物氧化分解成二氧化碳和水；氧化

The three chamber RTO incinerator is currently the mainstream application device, and its working principle is to heat the organic waste gas to above 760 degrees, so that the organic matter in the waste gas is oxidized and decomposed into carbon dioxide and water; Oxidation

反应产生的高温气体流经蓄热体，使蓄热体升温而“蓄热治，并用于预热后续进入的有机废气，从而节省废气升温所消耗的燃料量；蓄热体分为三

The high-temperature gas generated by the reaction flows through the heat storage body, which heats up the heat storage body and is used for "heat storage treatment", and is used to preheat the organic waste gas that enters later, thereby saving the fuel consumption for waste gas heating. The heat storage body is divided into three parts

个室，每个室依次经历“蓄热一放热一清扫冶等程序，周而复始，连续工作；蓄热室“放热治后立即引入适量洁净空气对该室进行清扫，待清扫完成

Each room undergoes a process of "heat storage, heat release, cleaning and smelting" in sequence, repeating and working continuously. After the heat release treatment of the heat storage room, an appropriate amount of clean air is immediately introduced to clean the room, and the cleaning is completed

后才能进入“蓄热治程序；处理后的尾气由风机引至排气筒排放。

Only then can it enter the "heat storage and treatment program"; the treated exhaust gas is led to the exhaust pipe by the fan for discharge.

使用条件：

Usage conditions:

（1)废气入RTO炉前根据其成分、热值等参数进行搭配，生产过程及设备检修吹扫过程中均建议保证焚烧炉始终处于稳定运行状态；

(1) Before entering the RTO furnace, the exhaust gas must be matched according to its composition, calorific value, and other parameters. During the production process and equipment maintenance and blowing process, it is necessary to ensure that the incinerator is always in a stable operating state;

（2）进料口须保持气密性，进料系统应处于微负压状态，防止气体逸出；

(2) The inlet must maintain airtightness, and the feeding system should be in a slightly negative pressure state to prevent gas from escaping;

（3炉膛实际运行温度建议高于760度，才可能达到99%以上破坏去除率；

The actual operating temperature of the furnace must be higher than 760 degrees in order to achieve a destruction removal rate of over 99%;

（4)燃烧室耐火材料的质量须达到相应的技术标准，技术性能应满足燃烧气氛的要求，并能够承受炉膛工作状态的交变热应力；

(4) The quality of refractory materials in the combustion chamber must meet the corresponding technical standards, and the technical performance should meet the requirements of the combustion atmosphere and be able to withstand the alternating thermal stress of the furnace working state;

（5配备自动监控及反馈系统，对主要工艺参数进行自动调节，并在线显示运行工况和尾气排放参数；

Equipped with an automatic monitoring and feedback system, the main process parameters are automatically adjusted, and the operating conditions and exhaust emission parameters are displayed online;

（6）安装防爆门或其他防爆设施，燃烧室后设置紧急排放烟囱，并设置联动装置使其只能在事故或紧急状态时才可启动。

(6) Install explosion-proof doors or other explosion-proof facilities, set up emergency exhaust chimneys behind the combustion chamber, and install linkage devices so that they can only be activated in case of accidents or emergencies.